Search:

Have you recently fitted a trailer plug ?
The Y61 will blow Hazard fuses with extra lights from trailer
to fix all that was required was a bigger fuse.
for you I'd break out the multi meter and...

25341

25342

Hope that helps

Cheers

Todd

The early 4.2s had no EGR system, probably why they last so long lol
Cheers, the ferret.

They are a bitch but once you figure t out they will come off easy.

You need to put the hub in a vice. Take off the seal from under the bearing if you can. You need to wreck the seal getting it...

100% ET, I just want to make sure it's not a problem with the battery sense circuit before I fully condemn the alternator.

Jason, As a general rule for an overhaul you would replace the bearings...

Hiya Jason

Yours is a 24 Volt system so both the Batteries are the Starter Battery as they are in Series.

Alternator Output still sounds too low to me and the "dripping filter" light is the...

99% You've either dropped an output phase (blown diode/s) or the excitation from the battery via the brushes is open cct and the slight rise in the output (warning lights dimming but still on) is due...

flush the alternator with water and wd40/innox it up also

Yes, check the connections at the batteries, the main earths to the engine and body and the connections at the back of the alternator.

Does the vehicle still start now? have you noticed your...

SUSPENSION;


RADIUS ARMS; The front radius arms are the arms which extend from the chassis forward to the front diff. Look for cracking or perishing of the bushes. To do this you will need a...

**BRAKES AND STEERING ARE CRITICAL SAFETY SYSTEMS DO NOT ATTEMPT TO SERVICE THESE SYSTEMS UNLESS YOU KNOW WHAT YOU ARE DOING**

BRAKES; The vast majority of GQ/GU Patrols (and Mavericks) were...

DRIVE LINE;

DIFFERENTIALS; First thing to check is oil leaks (note: oil leaks may also be caused by blocked breathers, see third paragraph). Oil leaking from the front of the diff where the tail...

There is a lot of information to put in here so this post/thread will keep growing over time, I'll add photos as I can.

This is by no means a complete or definitive guide, my aim is to give people...