Main seal leak ??

[1peter]

I have just bought a 98 GU Patrol with 159,000 km's on the clock in axcellent condition but I was aware of an oil leak which i thought may have been the main seal. When i took it for a roadworthy the guy pointed out that the tappet cover gasket was leaking badly and showed me all the oil running down the back of the motor, we figured that this is where the oil was comming from and fixed the gasket as part of the roadworthy. After having it at home for a few days i have noticed a few drips of oil comming from the hole in the bottom of the bell housing. I thought that it might be oil that has come from the rocker cover and had been trapped in the bell housing and slowly leaking out but i no longer think this is the case. Is this likely to be the main seal ? Is it likely to get worse fairly quickly if it is ??

[AB]

Hi mate, first off I would clean the engine thoroughly asap and then you'll be able to identify exactly where the leak is coming from and then you'll know where your at.

[YNOT]

There is no easy way to determine if the oil is trapped oil from the leaking rocker cover or a rear main. As AB suggested give the engine a thorough degreasing and keep an eye on it.
If it is a rear main it is unlikely to get rapidly worse.

Tony

[1peter]

The engine was cleaned before the rocker gasket was fitted so it could be leftover oil that got into the bell housing before it was cleaned (if that is possible) but I don't think so ?? it is only leaking a small amount over night (20 cent piece size patch on the ground) but i am wondering if should persue it at the roadworthy ?? Most of the work has been finished for the roadworthy but i have to go back and get a few little things done like a chip in the windscreen etc. I have the car at home and have paid my brother in law for it and he said he would pay for any problems that arise at the roadworthy and was previously aware that the main seal may have been leaking. I don't want him to have to pay $1000 to fix the main seal if it is not going to get worse for years to come but, i don't want to have to fork out $1000 myself either ?? What to do ??

[YNOT]

It's your call Peter. The oil leak you are describing above is very unlikely to residual oil - sounds like it is the rear main. Technically an oil leak that is dripping onto the ground is a roadworthy fail.
Maybe suggest splitting the cost of repairs with your BIL.

Tony

[1peter]

Yep, might be the answer.

[YNOT]

Not to throw a spanner in the works but consider fitting a new clutch while the gearbox is out.

Tony

[1peter]

It's an auto YNOT.

[growler2058]

Yep i wouldnt go changin the clutch then hahahaha

[1peter]

I might yet be lucky, the oil leak seems to be almost at a stop, so it might just be the oil that leaked down from the rocker cover and has gone into the bell housing ? Keeping my fingers crossed.

[Bigrig]

I might yet be lucky, the oil leak seems to be almost at a stop, so it might just be the oil that leaked down from the rocker cover and has gone into the bell housing ? Keeping my fingers crossed.

Good luck with it mate - all our fingers are firmly crossed for you!!

[1peter]

Well, it's been a week now and i think i might have the smallest main seal leak possible. It seems that when i drive to work and back "about 26km's round trip" one drop of oil hangs off the bell housing but doesn't even fall on the concrete over night ?? I wipe it off and the same thing happens the following day.

[1peter]

The truck is in the shop getting the main seal fixed and my brother in law has offered to pay for it "bless his heart" so i should get it back tomorrow.

[mike barnett]

i thought i had a rear main seal leak the other day so pulled the trans out in the driveway ,it turned out to be the front seal on the auto ,while it was out i got the torque converter reconed and did BOTH seals there is a small o ring seal on the shaft.would pay to do them while auto is out

[1peter]

Thanks, but too late. It is already done and mine was the main seal (no trans fluid leaking) but as you said it would have been good if the seals you speak of were replaced at the same time. Ah well, i will ask and find out if they did replace them but there was no mention of it.

[G-ForceCrew]

Hi Mate

If its still leaking and its a rear main the block after washing it will be dry above the sump and bell housing. Check the sump bolts to as these are only done up to about 8nm, as the gasket gets onlder they may need a little tweek up. Dont grunt them or they will snap off and another issue to deal with. Aquick fix for a rear main seal leak is rislone might get you a few more km's. You get it from super cheap autos in oz. Add it to the oil.It want work if you have score marks in the crank or the seal has fallen apart. I had an oil leak to and found one off the oil fillers was to loose.As the oil comming out was under pressure it was hard to find were it was comming from. Good idea to check these after the engine is hot.


Good Luck


Kel